>
Hyundai Equus Manuals

Hyundai Equus: Water pump Troubleshooting - Cooling System - Engine Mechanical System - Hyundai Equus VI 2009-2024 Service ManualHyundai Equus: Water pump Troubleshooting

Second generation VI (2009–2024) / Hyundai Equus VI 2009-2024 Service Manual / Engine Mechanical System / Cooling System / Water pump Troubleshooting

Troubleshooting
Water Pump
Symptoms
Possible Causes
Remedy
Coolant leakage
•
From the bleed hole of the water pump
Visually check
•
Check leaks after about ten-minute warming up.
•
If coolant still leaks, replace a water pump.
•
If leakage stops, reuse the water pump (Do not replace the pump with a new one).
•
From gaskets or bolts
•
Check the tightening of the water pump mounting bolts.
•
Retighten the mounting bolts.
•
Check damage of gaskets or inflow of dust.
•
Replace the gasket and clean dust off.
•
From outer surface of water pump
•
Check the material or any cracks of the water pump.
•
Poor material. If any crack found, replace the water pump.
Noise
•
From bearings
•
From mechanical seals
•
Impeller interference
Inspection with a stethoscope
•
After starting the engine, check noise with a stethoscope.
•
If there is no noise, reuse the water pump (do not replace it).
•
If there is any noise from the water pump, remove the drive belt and recheck.
Inspection after removing a drive belt
•
After removing a water pump and a drive belt, check noise again.
•
If there is noise, reuse the water pump. Check other drive line parts.
•
If there is no noise, replace the water pump with a new one.
Inspection after removing a water pump
•
After removing a water pump and a drive belt, check noise again.
•
If there is any interference between them, replace the water pump with a new one.
Overheating
•
Damaged impeller
•
Loosened impeller
Loosened impeller
•
Corrosion of the impeller wing
•
Check engine coolant.
•
Poor coolant quality / Maintenance check
•
Impeller seperation from the shaft
•
Replace the water pump.

    Water pump Repair procedures
    Removal and Installation Water Pump 1. Disconnect the negative terminal (A) from the battery. Tightening torque : 3.9 ~ 5.9 N.m (0.4 ~ 0.6 kgf.m, 2.9 ~ 4.3 lb-ft) 2. Remove the air du ...

    Thermostat Components and Components Location
    Components 1. Engine coolant temperature control assembly2. Engine coolant temperature control assembly gasket3. Water outlet fitting assembly4. Water outlet fitting assembly gasket5. Water outle ...

    See also:

    ETC (Electronic Throttle Control) System Troubleshooting
    Fail-safe mode ITEMSFAIL-SAFEETC MotorThrottle valve stuck at 5°TPSTPS 1 faultReplace it with TPS2TPS 2 faultReplace it with TPS1TPS 1,2 faultThrottle valve stuck at 5°APSAPS 1 faultReplace it wi ...

    G Sensor Schematic Diagrams
    Circuit diagram 1. G-sensor connector 2. G-sensor terminal function NoFunction1Signal2Ground3Power(5V) 3. Circuit diagram ...

    Components and Components Location
    Component Location 1. Engine room relay box (Rear glass defogger)2. Rear window defogger switch (A/C controller)3. Rear window defogger4. Body control unit ...

    Categories

    Hyundai Equus Manuals


    © 2011-2024 Copyright www.heqmanual.com