Hyundai Equus: Fuel Pump Control Module (FPCM) Description and Operation
Second generation VI (2009–2024) / Hyundai Equus VI 2009-2024 Service Manual / Engine Control/Fuel System / Fuel Delivery System / Fuel Pump Control Module (FPCM) Description and Operation
Second generation VI (2009–2024) / Hyundai Equus VI 2009-2024 Service Manual / Engine Control/Fuel System / Fuel Delivery System / Fuel Pump Control Module (FPCM) Description and Operation
| Description |
The fuel pump control module (FPCM) is installed on the right
side of the trunk compartment. It controls the BLDC (Brushless DC)
motor mounted inside the variable low pressure fuel pump. This module
compares the target fuel pressure data received from the ECM to the
current fuel pressure measured by the fuel pressure sensor (FPS) and,
based on the data from the FPS, controls the 3-phase duty function of
the low pressure fuel pump to generate the target pressure.
| Operation |
| 1. |
The ECM receives the target fuel pressure signal through CAN communication with the FPCM. |
| 2. |
The FPS applies the current low fuel pressure value to the FPCM. |
| 3. |
The FPCM controls the 3-phase duty function of the low pressure fuel pump. |
| 4. |
The FPS applies the current low fuel pressure value to the FPCM. |
| 5. |
It controls the low pressure fuel pump based on the RPM and vehicle load to provide a consistent flow rate. |
Over Pressure Valve (OPV) Repair procedures
Removal
1.
Turn the ignition switch OFF and disconnect the battery negative (-) cable.
2.
Release the residual pressure in fuel line.
(Refer to Fuel Delivery System -"Release Residual Pressu ...
Fuel Pump Control Module (FPCM) Specifications
Specification
ltemSpecificationSupply Voltage (V)8~18Supply Current (A)Max. 10Fuel Pressure (kpa)Starting600Drive350 ~ 500Stop20 Under
...
See also:
Don't neglect the interior
Moisture can collect under the floor mats and carpeting to cause corrosion. Check
under the mats periodically to be sure the carpeting is dry. Use particular care
if you carry fertilizers, cleanin ...
Manifold Absolute Pressure Sensor (MAPS) Schematic Diagrams
Circuit Diagram
...
Height Sensor Description and Operation
Description
The ground clearance sensor is one component of the ECS
system. This sensor is installed between the vehicle body and lower
suspension arm. It measures the ground clearance and sen ...
Categories
Hyundai Equus Manuals
© 2011-2024 Copyright www.heqmanual.com